Description : In case of a plate and frame filter press, filtrate flow through the cake follows __________ flow. (A) Plug (B) Turbulent (C) Laminar (D) None of these
Last Answer : (C) Laminar
Description : Flow of filtrate through the cake in a plate and frame filter press is best described by the __________ equation. (A) Kozeny-Carman (B) Hagen-Poiseuille’s (C) Fanning's (D) Kremser
Last Answer : (A) Kozeny-Carman
Description : Shell and leaf filter as compared to plate and frame filter (A) Entails less labor cost (B) Facilitates filtration under higher pressure (C) Provides more effective washing (D) All (A), (B) & (C)
Last Answer : (D) All (A), (B) & (C)
Description : __________ is used for producing a thick suspension from a thin slurry. (A) Cartridge filter (B) Rotary drum vacuum filter (C) Pressure filter thickener (D) Plate and frame filter press
Last Answer : (C) Pressure filter thickener
Description : Introduction of slurry in a plate and frame filter press is done through a plate in each frame. The plate of this filter has a __________ surface. (A) Plane (B) Curved (C) Ribbed (D) Either (A) or (B)
Last Answer : (C) Ribbed
Description : Which of the following is the most suitable filter for separation ofabrasive solids suspended in a corrosive liquid? (A) Sand bed filter (B) Plate and frame filter press (C) Vacuum filter (D) Batch basket centrifuge
Last Answer : (C) Vacuum filter
Description : Plate and frame filter press is usually made of (A) Mild steel (B) Cast iron (C) Stainless steel (D) Galvanised iron
Last Answer : (B) Cast iron
Description : The cake resistance increases steadily with the time of filtration in a plate and frame filter employing constant __________ filtration. (A) Rate (B) Pressure (C) Both (A) & (B) (D) Neither (A) nor (B
Last Answer : (C) Both (A) & (B)
Description : In continuous filtration (at a constant pressure drop), filtrate flow rate varies inversely as the (A) Square root of the velocity (B) Square of the viscosity (C) Filtration time only (D) Washing time only
Last Answer : (A) Square root of the velocity
Description : The basic filtration equation is given as dt/dV = (µ/A ∆P). [(α .CV/A) + Rm], where, V is volume of the filtrate; A is the filtration area, a is specific cake resistance, μ is viscosity of ... produced? Neglect filter medium resistance, Rm; assume incompressible cake. (A) 10 (B) 20 (C) 25 (D) 30
Last Answer : (B) 20
Description : Filtration rate through a filter cake is proportional to (where, S = filtering surface R = specific cake resistance μ = viscosity of the filtrate) (A) S (B) 1/R (C) 1/μ (D) All (A), (B) & (C)
Description : Filtrate flow rate in case of a rotary drum vacuum filter (in which Rm < < Rc ) is proportional to __________ and the cycle time (where, μ = filtrate viscosity Rm = filter medium resistance Rc = cake resistance). (A) √μ (B) 1/√μ (C) 1/μ (D) 1/μ
Last Answer : (B) 1/√μ
Description : Supporting legs of a plate and frame filter is normally made of (A) Stainless steel (B) Cast iron (C) High speed steel (D) Wooden plank
Description : For classification of potable (drinking) water, we use a __________ filter. (A) Gravity sand (B) Plate and frame (C) Vacuum leaf (D) Rotary vacuum
Last Answer : (A) Gravity sand
Description : For removal of very small amounts of precipitate from large volume of water, the most suitable filter is the __________ filter. (A) Plate & frame (B) Shell & lea (C) Sand (D) Rotary vacuum
Last Answer : (C) Sand
Description : For separation of sugar solution from settled out mud, we use a __________ filter. (A) Sparkler (B) Plate and frame (C) Centrifugal (D) Rotary drum vacuum
Last Answer : (C) Centrifugal
Description : Which of the following is a continuous filter? (A) Plate and frame filter (B) Cartridge filter (C) Shell and leaf filter (D) None of these
Last Answer : (D) None of these
Description : Gelatinous solid (which plug the septum) can be filtered by a __________ filter. (A) Sparkler (B) Plate and frame (C) Vacuum leaf (D) Pre-coat
Last Answer : (D) Pre-coat
Description : Removal of activated carbon from glycerine is done by (A) Plate and frame filter (B) Rotary vacuum filter (C) Batch basket centrifuge (D) None of these
Last Answer : (A) Plate and frame filter
Description : The most suitable filter for the removal of very small amount of precipitate from very large volumes of water is the __________ filter. (A) Vacuum (B) Sand (C) Plate & frame (D) Rotary
Last Answer : (B) Sand
Description : Filtration of water in a paper mill is done by a/an __________ filter. (A) Open sand (B) Plate and frame (C) Vacuum leaf (D) Sparkler
Last Answer : (A) Open sand
Description : Which is the best Plate filter press manufacturers in India?
Last Answer : Hydro Press Industries are one of the best plate filter press manufacturers in South India. With expert mechanism and efficiency the plate filter press from Hydro Press delivers quality and ... Products FILTER PRESS FERMENTER FILTER PLATE FILTER CLOTH FILTER PRESS SPARES FILTER PRESS FEED PUMP
Description : During filtration operation, the filtrate encounters the resistance of the (A) Filter medium (B) Cake (C) Channel carrying the slurry to the upstream side of the cake and filtrate away from the filter medium (D) All (A), (B) and (C)
Last Answer : (D) All (A), (B) and (C)
Description : During washing of filter at the end of constant pressure filtration, the rate of washing equals the rate of filtration (A) At time zero (B) At the end of filtration
Last Answer : (B) At the end of filtration
Description : Vacuum is applied in __________ zone, in case of a general type continuous rotary drum vacuum filter. (A) Filtering (B) Washing (C) Drying (D) All (A), (B) & (C)
Description : Filtration rate does not depend upon the (A) Pressure drop & area of filtering surface (B) Resistance of the cake & the septum (C) Properties of the cake & the filtrate (D) None of these
Description : The filtrate flow rate in constant pressure filtration (A) Continuously increases (B) Continuously decreases (C) Remain constant throughout (D) May increase or decrease; depends on the pressure
Last Answer : (B) Continuously decreases
Description : A straight line is obtained on plotting reciprocal of filtration rate vs. the volume of filtrate for __________ flow of filtrate. (A) Compressible cakes and laminar (B) Incompressible cake and laminar (C) Compressible cake and turbulent (D) Incompressible cake and turbulent
Last Answer : (B) Incompressible cake and laminar
Description : During the washing of cake (A) All the resistances are constant (B) Filter medium resistance increases (C) Filter medium resistance decreases (D) Cake resistance decreases
Last Answer : (A) All the resistances are constant
Description : Coal washing waste water containing about 3% suspended solids (comprising of clay, slate, stone etc.) is treated for solid particles removal (A) By chemical coagulation (B) In sedimentation tanks equipped with mechanical scrapper (C) In vacuum filter (D) In clarifiers
Last Answer : (B) In sedimentation tanks equipped with mechanical scrapper
Description : Insufficient washing of sand grains in a rapid sand filter causes (A) Air binding (B) Shrinkage of filtering media (C) Mud balls (D) Expansion of filtering media
Last Answer : (C) Mud balls
Description : Moore filter is a __________ filter. (A) Leaf (B) Press (C) Rotary (D) Sand
Last Answer : (A) Leaf
Description : Filtration should be stopped in a filter press, if the (A) Cake becomes very dense (B) Liquor stops flowing out to the discharge (C) Filtration pressure rises suddenly (D) Both (B) & (C
Last Answer : (D) Both (B) & (C
Description : A filter press is (A) A batch filter (B) Not suitable, if the liquid is the main product (C) Having prohibitively high maintenance cost (D) Not suitable for wide range of materials under varying operating conditions of cake thickness and pressure
Last Answer : (A) A batch filter
Description : Which of the following is a vacuum filter? (A) Filter press (B) Rotary disc filter (C) Batch basket centrifuge (D) Tank filter (Nutsche filter)
Last Answer : (B) Rotary disc filter
Description : Which of the following is a pressure filter? (A) Leaf filter (Moore filter) (B) Plate and flame filter
Last Answer : (B) Plate and flame filter
Description : Mud balls may be removed by (A) Breaking and washing (B) Washing the filter with a solution of caustic soda (C) Removing, cleaning and replacing the damaged sand (D) All the above
Last Answer : (D) All the above
Description : Filter medium resistance is important during the __________ of filtration. (A) Early stages (B) Final stages (C) Entire process (D) None of these
Last Answer : (A) Early stages
Description : Filter aids like asbestos, kieselguhr, diatomaceous earth etc. are used to increase the porosity of the final filter cake & reducing the cake resistance during filtration. Filter aid is (A) Added to the feed slurry (B) Pre ... the cake by dissolving solids or by burning it off (D) All 'a', 'b' & 'c'
Last Answer : (D) All 'a', 'b' & 'c'
Description : Write the working of filter press with well labelled diagram.
Last Answer : Working: 1. The slurry is pumped in under positive pressure up to 20 bar and fill each frame. 2. The filtrate passes through the cloths on opposite sides of the frame and runs down between the ... 6. Thickness of cake can be varied by using frame of different thickness. Diagram:
Description : Explain the construction and working of filter press.
Last Answer : Construction: It consists of alternative plate and frame mounted on two parallel support bars. The pressure can be applied through screw thread so that the plate and frame are rigidly fixed between ... Thickness of cake can be varied by using frame of different thickness. Diagram:
Description : When 40 c c of slightly moist hydrogen chloride gas is mixed with 20 c c of ammonia gas the final volume of gas left at the same temperature and press
Last Answer : When 40 c c of slightly moist hydrogen chloride gas is mixed with 20 c c of ammonia gas the final volume of gas left ... . 40 c c C. 60 c c D. 100 c c
Description : Frame the formula: final velocity (v) of a body in linear motion is equal to the sum of its initial velocity (u) and the product of acceleration (a) a
Last Answer : Frame the formula: final velocity (v) of a body in linear motion is equal to the sum of its initial velocity (u) and ... v=u-at C. v=u+at D. v=-u-at
Description : is not the component of sprayers. a) Swirl plate b) Filter c) Cut-off value d) Pump
Last Answer : Pump
Description : When a beam of ordinary white light is passed through a Polaroid plate filter, the intensity of the beam that emerges is: w) equal to that of the incident beam x) about 0.9 that of the incident beam y) about one-half that of the incident beam z) practically zero
Last Answer : ANSWER: Y -- ABOUT ONE-HALF THAT OF THE INCIDENT BEAM
Description : How can intermodulation interference between two transmitters in close proximity reduced or eliminated? A. Through installing a band-pass filter in the antenna feed line B. Through installing terminated circulator ... high driving power D. By installing a low-pass filter in the antenna feed line
Last Answer : A. Through installing a band-pass filter in the antenna feed line
Description : Which of the following represents the plot of filtrate volume versus time for constant pressure filtration? (A) Parabola (B) Straight line (C) Hyperbola (D) Exponential curve
Last Answer : (A) Parabola
Description : . For laminar flow of filtrate through the cake deposited on septum, which of the following will be valid? (A) Kozeny-Carman equation (B) Leva's equation (C) Blake-Plummer equation (D) None of these
Last Answer : (A) Kozeny-Carman equation
Description : A final amplifier of a radio transmitter draws 250 mA of plate current when the plate supply voltage is 1400 volts. If the plate circuit efficiency is 80% and the transmitter is connected to an antenna having a feed impedance of 70 ohms, ... at the feed-point? A. 4.0 A B. 2.2 A C. 1.25 A D. 2.0 A
Last Answer : D. 2.0 A
Description : For what class of operation is the final rf power amplifier of a plate-modulator circuit biased?
Last Answer : Class C